ICE3PCS01G Infineon Technologies, ICE3PCS01G Datasheet
ICE3PCS01G
Specifications of ICE3PCS01G
Available stocks
Related parts for ICE3PCS01G
ICE3PCS01G Summary of contents
Page 1
...
Page 2
... Infineon Technologies Office. Infineon Technologies components may be used in life-support devices or systems only with the express written approval of Infineon Technologies failure of such components can reasonably be expected to cause the failure of that life-support device or system or to affect the safety or effectiveness of that device or system. Life support devices or systems are intended to be implanted in the human body or to support and/or maintain and sustain and/or protect human life ...
Page 3
... ICE3PCS01G PG-DSO-14 Version 2.0 Description The ICE3PCS01G is a 14-pins wide input range controller IC for active power factor correction converters de- signed for converters in boost topology, and requires few external components. Its power supply is recommended to be provided by an external auxiliary supply which will switch on and off the IC ...
Page 4
... Operating Range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 4.3 Characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 4.3.1 Supply Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 4.3.2 Variable Frequency Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 4.3.3 PWM Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 4.3.4 External Synchronization . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 4.3.5 PFC Brownout Protection Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 4.3.6 System Protection Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 4.3.7 Internal Voltage Reference . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 4.3.8 Boost Follower Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 Version 2.0 4 CCM-PFC ICE3PCS01G 5 May 2010 ...
Page 5
... Bulk Voltage Good Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 4.3.10 Current Loop Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 4.3.11 Voltage Loop Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 4.3.12 Driver Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 4.3.13 Gate Drive Section . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 5 Outline Dimension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 Notes Version 2.0 5 CCM-PFC ICE3PCS01G 5 May 2010 ...
Page 6
... VBTHL_EN to set the turn-off threshold of VB_OK signal. The IC can be shut down by pulling the pin lower VREF than 0.5V VREF (Voltage Reference) This pin is the 5V regulator output with a 5mA sourcing current (minimum). 6 CCM-PFC ICE3PCS01G ). This is the input signal SHUNT , driving currents out of SHUNT ) of around 50Ω May 2010 ...
Page 7
... VCC provides the power supply of the ground related to IC section. GATE GATE is the output for driving the PFC MOSFET.Its gate drive voltage is clamped at 15V (typically). PGND (Power Ground) Gate switching ground. Version 2.0 Pin Configuration and Functionality over voltage 7 CCM-PFC ICE3PCS01G 5 May 2010 ...
Page 8
... Block Diagram A functional block diagram is given in Figure 2. Note that the figure only shows the brief functional block and does not represent the implementation of the IC. Figure 2 Block Diagram Version 2.0 8 CCM-PFC ICE3PCS01G Block Diagram 5 May 2010 ...
Page 9
... IPP60R199CP MUR360 IDT04S60C 220µF/450V 1N4007 3.9MΩ 130kΩ 3µF 30mΩ 1nF 50Ω 3.3Ω 67kΩ 4.7nF/25V 1.5MΩ 18.85kΩ 2MΩ 23kΩ 330kΩ 200kΩ 100nF/25V 200kΩ 9 CCM-PFC ICE3PCS01G Block Diagram 5 May 2010 ...
Page 10
... Functional Description 3.1 General The ICE3PCS01G is a 14-pins control IC for power factor correction converters suitable for wide range line input applications from 85 to 265 VAC with overall efficiency above 90%. The IC supports converters in boost topology and it operates in continuous conduction mode (CCM) with average current control. ...
Page 11
... The Proportion-Integration (PI) compensation of the voltage loop is integrated digitally inside the IC. The digital data out of the PI compensator is converted to analog voltage for current loop control. 11 CCM-PFC ICE3PCS01G Functional Description Voltage Loop . This loop is closed by the feedback OUT . The pin VSENSE is the input of OUT ...
Page 12
... OFF From the above equation, D The objective of the current loop is to regulate the average inductor current such that it is proportional to the off duty cycle Figure 9 shows the scheme to achieve the IN objective. 12 CCM-PFC ICE3PCS01G Functional Description L Boost GATE R shunt CS Current Loop voltage ...
Page 13
... PWM Cycle which may exceed the maximum design values of the input current. ICE3PCS01G provides a new BOP feature whereby it senses directly the input voltage for Input Brown-Out condition via an external resistor/capacitor/diode network shown in Figure 12. This network provides a filtered value of VIN which turns the IC on when the voltage at pin 9 (BOP) is more than 1 ...
Page 14
... BOFO voltage is less than 0.5V. Once these two conditions are met in the same time, a 20µA current source is flowing out of pin VSENSE so that the bulk voltage should be reduced to a lower level in order 14 CCM-PFC ICE3PCS01G Functional Description Second Over Voltage Protection (OVP2) Bulk Voltage Monitor ...
Page 15
... Version 2.0 VCC PWM Logic Bulk HIGH to 20uA turn on R BVS 1 VSENSE R BVS 2 R BVS 3 * LV: Level Shift Figure 15 Gate Driver , the gate CCUVLO 15 CCM-PFC ICE3PCS01G Functional Description Reg (17V) Gate Driver LV External Z1 MOS GATE 5 May 2010 ...
Page 16
... OVP2 mode IC enters soft-restart mode after OVP2 detection released. 18 µs OVP2 mode IC enters latch mode after OVP2 released. detection 9 µs Disable Power down. Soft-restart after disable signal is function released. 16 CCM-PFC ICE3PCS01G Functional Description UVLO CC 5 May 2010 ...
Page 17
... VBTHL V -0.3 5.3 BOFO V -0.3 5.3 OVP T -40 150 J T -55 150 A,STO R 140 THJA T 260 SLD V 2 ESD 17 CCM-PFC ICE3PCS01G Electrical Characteristics Unit Note / Test Condition V V Clamped at 15V if driven internally µ °C °C K/W Junction to Air 3) °C Wave Soldering ...
Page 18
... CCUVLO V 0.7 1 CChy I - 380 CCstart1 - 1.4 I CCstart2 I - 6.7 CCHG - 3.5 I CCStdby 18 CCM-PFC ICE3PCS01G Electrical Characteristics Unit Note / Test Condition Max =25°C J 125 °C 250 kHz = 18V, a typical switching frequency VCC Unit Note/Test Condition Max. 12.9 V 11.9 V 1.45 V µA 700 V -1 ...
Page 19
... Min. Typ. Max. V 2.5 thr_EXT f 50 150 EXT_range f :f 1:1 EXT PFC T 500 EXT2GATE D_on 19 CCM-PFC ICE3PCS01G Electrical Characteristics Unit Test Condition kHz R5 = 67kΩ kHz R5 = 212kΩ kHz R5 = 17kΩ SWnom (R =67kΩ) FRE Unit Test Condition % V = 2.5V VSENSE V = 4.3V ...
Page 20
... PCL T 200 PCLon Symbol Values Min. Typ. Max. V 4.9 5 5.1 VREF_0A ∆V 50 VREF_5mA ∆V 25 VREF_VCC 20 CCM-PFC ICE3PCS01G Electrical Characteristics Unit Note / Test Condition V V µs µA V =1.25V BOP Unit Note / Test Condition V 108%V BULKRated V mV µ µs V comparator at VBTHL pin µ ...
Page 21
... VBOKon V V VBOKoff VBTHL_EN V 0.45 0.5 0.55 VBTHL_EN T 9 VBTHL_EN VB_OKMax 21 CCM-PFC ICE3PCS01G Electrical Characteristics Unit Note / Test Condition mA % Line, Load, Temperature Unit Note / Test Condition V kΩ µs µA Unit Note / Test Condition 2.5 V sensed at pin VSENSE V set by pin VBTHL_EN V µ ...
Page 22
... GATEH - 12 Symbol Values Min. Typ. Max CCM-PFC ICE3PCS01G Electrical Characteristics Unit Note / Test Condition mS At Temp = 25°C µ 0.4V VSENSE Unit Note / Test Condition V ±1.2% V µ 2.5V VSENSE Unit Note / Test Condition V V =10V GATE GATE GATE ...
Page 23
... Does not include plastic or metal protrusion of 0.15 max. per side Notes: 1. You can find all of our packages, sorts of packing and others in our Infineon Internet Page “Products”: http://www.infineon.com/products. 2. Dimensions in mm. Version 2.0 0.33 4 -0.2 C 0.1 0 14x -0 CCM-PFC ICE3PCS01G Outline Dimension x 45˚ ±0.08 1) 0.64 ±0.25 6 ±0.2 5 May 2010 ...
Page 24
... Geben Sie uns die Chance, hohe Leistung durch umfassende Qualität zu beweisen. Wir werden Sie überzeugen Published by Infineon Technologies AG Quality takes on an allencompassing significance at Semiconductor Group. For us it means living up to each and every one of your demands in the best possible way are not only concerned with product quality ...