IR21363PBF International Rectifier, IR21363PBF Datasheet

no-image

IR21363PBF

Manufacturer Part Number
IR21363PBF
Description
3 Phase Driver, Soft Turn-on, Inverting Input Separate High and Low Side Inputs, 200ns Deadtime.
Manufacturer
International Rectifier
Datasheet
1.IR21363J.pdf (27 pages)

Specifications of IR21363PBF

Family Hvic
General Purpose HVICs
Channels
6
Topology
Three Phase
Application
General Purpose / Motor Control / PDP
Voffset
600
Io+ (ma)
200
Io- (ma)
350
Shutdown / Reset
Yes
Separate Power And Logic Ground
Yes
Over Current Protection
Yes
Uvlo
Vcc / Vbs
Vbsuv+ / Vccuv+ Min (v)
10.6
Vbsuv+ / Vccuv+ Typ (v)
11.1
Vbsuv+ / Vccuv+ Max (v)
11.6
Vbsuv- / Vccuv- Min (v)
10.4
Vbsuv- / Vccuv- Typ (v)
10.9
Dt / Sdt Min (ns)
220
Dt / Sdt Typ (ns)
290
Dt / Sdt Max (ns)
360
T On Min (ns)
300
T On Typ (ns)
425
T On Max (ns)
550
T Off Min (ns)
250
T Off Typ (ns)
400
T Off Max (ns)
550
Fault Reporting
Yes
Inverter Input Logic
LIN / HIN
Package
28 or 44 Lead
Part Status
Active & Preferred
Features
Description
The IR21363(J&S) are high votage, high speed power MOSFET and IGBT drivers with three independent high and
low side referenced output channels for 3-phase applications. Proprietary HVIC technology enables ruggedized
monolithic construction. Logic inputs are compatible with CMOS or LSTTL outputs, down to 3.3V logic. A
current trip function which terminates all six outputs can be derived from an external current sense resistor. An
enable function is available to terminate all six outputs simultaneously. An open-drain FAULT signal is provided
to indicate that an overcurrent or undervoltage shutdown has occurred. Overcurrent fault conditions are cleared
automatically after a delay programmed externally via an RC network connected to the RCIN input. The output
drivers feature a high pulse current buffer stage designed for minimum driver cross-conduction. Propagation
delays are matched to simplify use in high frequency applications. The floating channel can be used to drive N-
channel power MOSFETs or IGBTs in the high side configuration which operates up to 600 volts.
Typical Connection
www.irf.com
(Refer to Lead Assignments for correct pin configuration). This/These diagram(s) show electrical connections only.
Please refer to our Application Notes and DesignTips for proper circuit board layout.
Floating channel designed for bootstrap operation
Fully operational to +600V
Tolerant to negative transient voltage - dV/dt immune
Gate drive supply range from 12 to 20V
Undervoltage lockout for all channels
Over-current shutdown turns off all six drivers
Independent 3 half-bridge drivers
Matched propagation delay for all channels
Cross-conduction prevention logic
Lowside outputs out of phase with inputs. High side
outputs out of phase
3.3V logic compatible
Lower di/dt gate driver for better noise immunity
Externally programmable delay for automatic fault clear
HIN1,2,3
LIN1,2,3
HIN1,2,3
FAULT
VCC
GND
EN
VCC
HIN1,2,3 / HIN1,2,3
LIN1,2,3
FAULT
EN
RCIN
ITRIP
VSS
HO1,2,3
VS1,2,3
LO1,2,3
VB1,2,3
COM
3-PHASE BRIDGE DRIVER
IR2136(2)(3)(5)(6)(7)(8)
Packages
28-Lead SOIC
44-Lead PLCC w/o 12 leads
IR21363 ( J & S)PbF
Data Sheet No. PD60245
up to 600V
28-Lead PDIP
LOAD
TO
1

Related parts for IR21363PBF

Image
Part Number
Description
Manufacturer
Datasheet
Request R
IR2136
Part Number:
IR2136
Description:
IC DRIVER BRIDGE 3-PHASE 28-DIP
Manufacturer:
International Rectifier
Datasheet:
IR21362JTRPBF.pdf (36 pages)
80CNQ045
Part Number:
80CNQ045
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
80CNQ045.pdf (6 pages)
82CNQ030
Part Number:
82CNQ030
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
82CNQ030.pdf (6 pages)
85CNQ015
Part Number:
85CNQ015
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
85CNQ015.pdf (8 pages)
200CNQ035
Part Number:
200CNQ035
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
200CNQ035.pdf (5 pages)
120NQ045
Part Number:
120NQ045
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
120NQ035R.pdf (5 pages)
400CNQ045
Part Number:
400CNQ045
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
400CNQ045.pdf (4 pages)
63CNQ100
Part Number:
63CNQ100
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
63CNQ100.pdf (2 pages)
123NQ080
Part Number:
123NQ080
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
123NQ080.pdf (5 pages)
301CNQ045
Part Number:
301CNQ045
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
301CNQ045.pdf (5 pages)
125NQ015
Part Number:
125NQ015
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
125NQ015.pdf (4 pages)
301CNQ040
Part Number:
301CNQ040
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
301CNQ045.pdf (5 pages)
123NQ100
Part Number:
123NQ100
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
123NQ080.pdf (5 pages)
241NQ045
Part Number:
241NQ045
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
241NQ045.pdf (5 pages)
181NQ045
Part Number:
181NQ045
Description:
SCHOTTKY RECTIFIER
Manufacturer:
International Rectifier Corp.
Datasheet:
181NQ045.pdf (4 pages)

IR21363PBF Summary of contents

Page 1

Features Floating channel designed for bootstrap operation Fully operational to +600V Tolerant to negative transient voltage - dV/dt immune Gate drive supply range from 12 to 20V Undervoltage lockout for all channels Over-current shutdown turns off all six drivers Independent ...

Page 2

IR21363 ( J&S)PbF Absolute Maximum Ratings Absolute maximum ratings indicate sustained limits beyond which damage to the device may occur. All voltage parameters are absolute voltages referenced to COM. The thermal resistance and power dissipation ratings are measured under board ...

Page 3

Static Electrical Characteristics 1,2,3) = 15V unless otherwise specified. The V BIAS CC BS are applicable to all six channels (H 1,2,3 and L S and are applicable to the respective output leads: H Symbol Definition ...

Page 4

IR21363 ( J&S)PbF Dynamic Electrical Characteristics 15V BIAS S1,2,3 Symbol Definition t on Turn-on propagation delay t off Turn-off propagation delay t r Turn-on rise time t f Turn-off ...

Page 5

Functional Block Diagram INPUT HIN1 NOISE FILTER SHOOT-THROUGH INPUT LIN1 NOISE FILTER INPUT HIN2 NOISE FILTER SHOOT-THROUGH INPUT LIN2 NOISE FILTER INPUT HIN3 NOISE FILTER SHOOT-THROUGH INPUT LIN3 NOISE FILTER VSS INPUT EN NOISE FILTER INPUT ITRIP + NOISE - ...

Page 6

IR21363 ( J&S)PbF Lead Definitions Symbol Description V Low side and logic fixed supply CC VSS Logic Ground HIN1,2,3 Logic inputs for high side gate driver outputs (HO1,2,3), out of phase LIN1,2,3 Logic inputs for low side gate driver outputs ...

Page 7

HIN1,2,3 HIN1,2,3 LIN1,2,3 EN ITRIP FAULT RCIN HO1,2,3 LO1,2,3 LIN1,2,3 50% HIN1,2 LIN1,2,3 50% HIN1,2,3 ton tr PW HO1,2,3 90% LO1,2,3 10% Figure 2. Switching Time Waveforms www.irf.com Figure 1. Input/Output Timing Diagram 50% EN 50% HO1,2,3 toff ...

Page 8

IR21363 ( J&S)PbF LIN1,2,3 HIN1,2,3 LIN1,2,3 HIN1,2,3 LO1,2,3 HO1,2,3 Figure 4. Internal Deadtime Timing Waveforms RCIN ITRIP FAULT Any output on HIN/LIN HO/LO www.irf.com 50% 50% 50% 50% 50% DT 50% 50% 50% 50% tflt tfltclr 90% titrip Figure 5. ...

Page 9

M ax. 100 Typ. 0 -50 - Temperature ( Figure 6A. Turn-on Rise Time vs. Temperature 200 150 100 M ax. 50 Typ. 0 -50 - Temperature ( C) ...

Page 10

IR21363 ( J&S)PbF 1000 800 600 M ax. Typ. 400 200 0 -50 - Temperature ( Figure 8A Output Shutdown Time vs. Temperature 1000 800 M ax. 600 Typ. 400 M ...

Page 11

M ax. 900 Typ. 600 300 Supply Voltage (V) Figure 9B. ITRIP to Output Shutdown Time vs. Supply Voltage 1200 1000 M ax. 800 Typ. 600 400 ...

Page 12

IR21363 ( J&S)PbF 3.0 2.5 M ax. 2.0 Typ. 1 1.0 0 Supply Voltage (V) Figure 11B. FAULT Clear Time vs. Supply Voltage 600 500 M ax. 400 Typ. 300 ...

Page 13

M ax Supply Voltage (V) Figure 13B. Logic “0” Input Threshold vs. Supply Voltage Supply ...

Page 14

IR21363 ( J&S)PbF 800 700 600 M ax. 500 Typ. 400 300 200 Supply Voltage (V) Figure 15B. ITRIP Positive Going Threshold vs. Supply Voltage 3.0 2.5 2.0 M ax. 1.5 Typ. 1.0 ...

Page 15

M ax Typ Supply Voltage (V) Figure 17B. Low Level Output vs. Supply Voltage ax. 11 Typ ...

Page 16

IR21363 ( J&S)PbF 500 400 300 200 100 M ax. 0 100 200 300 400 V Boost Voltage (V) B Figure 20B. Offset Supply Leakage Current vs. V Boost Voltage B 250 200 150 100 M ax. 50 Typ. 0 ...

Page 17

M ax. 200 Typ Supply Voltage (V) Figure 22B. Logic “1” Input Current vs. Supply Voltage 600 500 400 300 200 M ax. 100 Typ Supply Voltage ...

Page 18

IR21363 ( J&S)PbF 250 200 150 M ax. 100 50 Typ Supply Voltage (V) Figure 24B. “High” ITRIP Current vs. Supply Voltage ax. 1 Typ Supply ...

Page 19

M ax. 100 50 Typ Supply Voltage (V) Figure 26B. “High” IEN Current vs. Supply Voltage ax. 1 Typ Supply Voltage (V) Figure ...

Page 20

IR21363 ( J&S)PbF ax. 1 Typ Supply Voltage (V) Figure 28B. RCIN Input Bias Current vs. Supply Voltage 500 400 300 200 Typ. 100 ...

Page 21

Typ. 200 100 Supply Voltage (V) Figure 30B. Output Sink Current vs. Supply Voltage 250 200 150 M ax. 100 Typ Supply ...

Page 22

IR21363 ( J&S)PbF 250 200 150 M ax. 100 Typ Supply Voltage (V) Figure 32B. FAULT Low On-resistance vs. Supply Voltage www.irf.com 0 -3 Typ -12 - Figure ...

Page 23

Frequency (KHz) Figure 34. IR21363 vs. Frequency (IRG4BC20W), R gat e=33 , Vcc=15V 120 100 0 Frequency (KHz) Figure 36. IR21363 vs. Frequency (IRG4BC40W), R gat ...

Page 24

IR21363 ( J&S)PbF 120 100 0 Frequency (KHz) Figure 38. IR21363 (J) vs. Frequency (IRG4BC20W), R gat e=33 , Vcc=15V 120 100 0.1 1 Frequency (KHz) Figure 40. IR21363 (J) ...

Page 25

Frequency (KHz) Figure 42. IR21363 (S) vs. vs. Frequency (IRG4BC20W), R gat e=33 , Vcc=15V 120 100 0 Frequency (KHz) Figure 44. IR21363 (S) vs. ...

Page 26

IR21363 ( J&S)PbF Case outlines www.irf.com 28-Lead PDIP (wide body) 28-Lead SOIC (wide body) 01-6011 01-3024 02 (MS-011AB) 01-6013 01-3040 02 (MS-013AE) 26 ...

Page 27

PLCC w/o 12 leads WORLD HEADQUARTERS: 233 Kansas Street, El Segundo, California 90245 Tel: (310) 252-7105 http://www.irf.com/ Data and specifications subject to change without notice. www.irf.com IR21363 ( J&S)PbF NOTES 01-6009 00 01-3004 02(mod. ) (MS-018AC) 11/3/2005 27 ...

Related keywords