SG6849-65DZ System General Corporation, SG6849-65DZ Datasheet
SG6849-65DZ
Available stocks
Related parts for SG6849-65DZ
SG6849-65DZ Summary of contents
Page 1
... MOS from over-voltage damage. The built-in over temperature protection (OTP) function will shutdown the controller at 150°C with a 20°C hysteresis. The SG6849 is designed to provide a low-cost total solution for flyback converters available in a small footprint, 6-pin, SOT-26 package. ...
Page 2
... XXXXXX: Wafer Lot YY: Year WW: Week V: Assembly Location ORDERING INFORMATION Part Number PWM Frequency SG6849-65T 65kHz SG6849-65D 65kHz SG6849-65TZ 65kHz SG6849-65DZ 65kHz PIN DESCRIPTIONS Pin No. Name Type DIP-8 SOT-26 GATE 1 6 Driver Output The totem-pole output driver to drive the power MOSFET. VDD 2 ...
Page 3
... DIP-8(SOT-26) © System General Corp. Version 1.4(IRO33.0002.B7) OTP SENSE S Q OSC PWM R Comp Slope Compensation OCP Comp Green Mode Controller - 3 - Product Specification V DD Driver 1( Power Blanking 4(4) SENSE Limiter Circuit 4.5V Σ 7(2) VDD VDDZ www.sg.com.tw SG6849 GATE FB Nov.01, 2005 ...
Page 4
... V -0 300 mW 263.3 °C/W 135.7 119.6 °C/W 67.1 °C 150 °C -55 to +150 SOT-26 220 °C DIP-8 260 3.0 kV 300 V Value Unit V <22.7 °C -30 to +85 Min. Typ. Max. 1.15 1.4 4.5 2 ≧ DDZ www.sg.com.tw Nov.01, 2005 SG6849 Unit mA V kΩ ...
Page 5
... Symbol Parameter TPD Propagation Delay V Current Limiting Valley Threshold Voltage for 65kHz TH,VA High-Line Sense Voltage Oscillator Section Symbol Parameter F SG6849–65 Frequency OSC F Green-Mode Burst Back Frequency* OSC-G-BK F Green-Mode OFF Frequency* OSC-G-OFF I Green-Mode OFF FB Input Current FB-G-OFF F Frequency Variation versus V ...
Page 6
... V = 15V 1nF 15V 1nF 20V DD Test Condition *1 *2 Test Condition V = 15V 15V DD GATE is Open I = 10mA Product Specification SG6849 Min. Typ. Max. Unit 310 ns 1 200 16 Min. Typ. Max. Unit °C 150 °C 130 Min. ...
Page 7
... TEMPERAT URE ( ℃ ) Maximum Duty Cycle (DCY ) vs. Temperature MAX 80.0 78.0 76.0 74.0 72.0 70.0 -40 -25 - EMPERATURE ( ℃ ) Valley Threshold Voltage (V ) vs. Temperature TH,VA 0.80 0.78 0.76 0.74 0.72 0.70 -40 -25 - EMPERATURE ( ℃ ) SG6849 =15. 110 125 V =15. 110 125 V =15. 110 125 www.sg.com.tw Nov.01, 2005 ...
Page 8
... TEMPERAT URE ( ℃ ) Green-Mode Burst Back(F ) and Green-Mode OSC-G-BK OFF Frequency(F ) vs. V OSC-G-OFF 30.0 F OSC-G-BK 25.0 20.0 15.0 10.0 5.0 0 Ramp vs. Duty Cycle LIMIT 1.10 1.05 1.00 0.95 0. Duty Cycle (%) SG6849 ) vs. 95 110 125 DD F OSC-G-OFF 9 =15. www.sg.com.tw Nov.01, 2005 ...
Page 9
... PWM output once the junction temperature exceeds 150°C. While PWM output is shut down, the V voltage will gradually drop to the UVLO voltage. Some of the SG6849’s internal circuits will be shut down, and V will gradually start increasing again. When V 17V, all the internal circuits, including the temperature sensing circuit, will start operating normally. If the junction temperature is still higher than 150° ...
Page 10
... Over a wide range of AC input voltages, the variation can be significant. To compensate for this, the threshold voltage is adjusted by adding a positive ramp. This ramp signal can vary from 0.77V to 1.05V for SG6849-65, and it flattens out at 1.05V. A smaller threshold voltage forces the output GATE drive to terminate earlier, thus reducing total PWM turn-on time and making the output power equal to that of the low line input ...
Page 11
... R10 3,4 CY1 Component 20mH 6*8mm 10uH 6mm MOSFET 1A/600V R 750kΩ 1206 R 47kΩ 1206 R 47Ω 1206 R 4.7Ω 1206 R 100Ω 0805 R 10Ω 1206 R 10Ω 1206 EE-16 IC SG6849 (Green PWM IC) www.sg.com.tw Nov.01, 2005 SG6849 VO GND ...
Page 12
... C8 D5 3,4 R11 U2 1 R14 2 C10 U3 CY1 1 Component 10uH 6mm MOSFET 1A/600V 750k 1206 47k/1206 47 1206 3.7 1206 100 0805 10 1206 5 1206 100 1/8W 33k 0805 33k 1/8W 4.7k 0805 EE-16 SG6849 (Green PWM IC) PC817 TL431 10uH 6mm www.sg.com.tw SG6849 Vo C9 GND R13 R12 Nov.01, 2005 ...
Page 13
... Product Specification Detail θ L1 Detail A Typ. Max. 0.057 0.006 0.045 0.051 0.020 0.009 0.114 0.110 0.063 0.037 0.075 0.018 0.24 0.024 0.010 0.25 4˚ 8˚ 10˚ 15˚ SG6849 www.sg.com.tw Nov.01, 2005 ...
Page 14
... Product Specification SG6849 Θ Typ. Max. 0.210 0.130 0.135 0.060 0.018 0.365 0.400 0.300 0.250 0.255 0.100 0.130 0.150 0.355 0.375 7 15 www ...
Page 15
... RIGHT TO MAKE CHANGES System General reserves the right to change this document and/or this product without notice. Customers are advised to consult their System General sales representative before ordering. © System General Corp. Version 1.4(IRO33.0002.B7) DISCLAIMERS - 15 - Product Specification SG6849 www.sg.com.tw Nov.01, 2005 ...