CMLV12S15-150 Wall Industries,Inc., CMLV12S15-150 Datasheet
CMLV12S15-150
Related parts for CMLV12S15-150
CMLV12S15-150 Summary of contents
Page 1
... Low input voltage converters are uncommon in the industry and the CMLV12S15-150 offers the flexibility of operation with both 12V and 24V busses. This state-of- the-art converter’s features include fast transient response, short circuit protection, over current protection, soft start, and many other features that are required for today’ ...
Page 2
... ON/OFF (0V) to Vout (min) 1 minute 1 minute 1 minute Max. Ambient limited by OTP Case Temperature Greater than Case Temperature Less than Calculated Using Bellcore TR-332 Method 1 case 3 www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 CMLV12S15-150 Min Nom Max - 400 - ...
Page 3
... ALUMINUM ALLOY 3003-0, PER: QQA 250/2. 3. UNLESS OTHERWISE SPECIFIED. (888) 597-WALL Rev ORDER: 4. UNIT COMES WITH EITHER 3M x 0.5 THREADED THRU INSERTS OR FOR Ø.125 THRU-HOLE FOR THE CHASSIS MOUNT BOARD ADD: “TH” SUFFIX TO MODEL PART NUMBER. EXAMPLE: CMLV12S15-150TH www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 Page ...
Page 4
... The converter has the ability to be remotely turned ON or OFF. The CMLV series is Active-High. Active-High means that a logic high at the ON/OFF pin will enable the supply (Figure 2). With Active-High, if the ON/OFF pin is left floating, the supply will be enabled. (888) 597-WALL Rev. A Figure 2: Active-High CMLV Series Converter www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 Page ...
Page 5
... Trim High Vo RTH 15.150 2575.44 All in Kohms 15.300 1297.94 15.450 872.11 15.600 659.19 15.750 531.44 15.900 446.27 16.050 385.44 16.200 339.81 16.350 304.33 16.500 275.94 www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 o (in Kohms) R lim onom (in Kohms) +V out +Rs Pins Facing Down Trim -Rs -V out ...
Page 6
... Table 2 from each TRIM pin to ±RS pin, or alternatively, a single resistor of half the value of Table 2 from the common TRIM pins to the common ±RS pins. (888) 597-WALL Rev schottky diode must be placed at the +Vo pin of each supply as shown in f Figure 5: Paralleling Converters www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 Page ...
Page 7
... Rev. A Graph 1: CMLV12S15-150 Efficiency vs. Output Current (A) o Graph 2: CMLV12S15-150 Max Ambient vs. Io (Vin=12V) No Airflow w ith 400lfm Air -20 - Ambient (°C) www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 Vin=10V Vin=12V Vin=24V Vin=30V ...
Page 8
... Rev. A Graph 4: CMLV12S15-150 Power Dissipation vs. Input Voltage 38 Io=0A 35 Io=1A Io=2A 32 Io=4A Io=6A 29 Io=8A 26 Io=10A (V) Graph 6: CMLV12S15-150 "Remote Off" Input Current and 5.9 5.6 5.3 5.0 4.7 4.4 4.1 3.8 3.5 3.2 2 www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 Io=1A Io= (V) in Power Dissipation vs. Input Voltage ...
Page 9
... Graph 7: CMLV12S15-150 Load Regulation (±RS Pins Open) 0.23% 0.22% 0.21% Vin=10V 0.20% Vin=12V Vin=24V 0.19% Vin=30V 0.18% 0.17% 0.16% 0.15% 0.14% 0.13% 0.12% 0.11% 0.10% 0.09% 0.08% 0.07% 0.06% 0.05% 0.04% 0.03% 0.02% 0.01% 0.00 Graph 9: CMLV12S15-150 Line Regulation (+RS to +Vo, -RS to -Vo) 0.20% 0.19% Io=1A Io=2A 0.18% Io=4A 0.17% Io=6A 0.16% Io=8A 0.15% Io=10A 0.14% 0.13% 0.12% 0.11% 0.10% 0.09% 0.08% 0.07% 0.06% 0.05% 0.04% 0.03% 0.02% 0.01% 0.00 Note: Voltage measurements taken where the output pins are soldered into test board. (888) 597-WALL Rev (A) Graph 10: CMLV12S15-150 Line Regulation (±RS Pins Open) ...
Page 10
... TEST SETUP: The CMLV12S15-150 specifications are tested with the following configurations: Regulation and Efficiency Setup To ensure that accurate measurement are taken, the voltage measurements are taken directly at the terminal of the module. This minimizes errors due to contact and trace lengths between the load and the output of the supply. The following is a diagram of the test setup ...
Page 11
... Airflow should be aligned lengthwise to the converter for optimum heat transfer. Contact Factory for derating curves. (888) 597-WALL Rev. A Figure 9: Airflow Orientation +V in Pins Facing Down CMLV12S15-150 ON/OFF -V in www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 +V out -V out Page ...
Page 12
... Input Voltage Single Output Nominal Output Voltage (603)778-2300 Phone: (888)587-9255 Toll Free: (603)778-9797 Fax: E-mail: sales@wallindustries.com Web: www.wallindustries.com Address: 5 Watson Brook Rd. Exeter, NH 03833 www.wallindustries.com TECHNICAL DATASHEET CMLV12S15-150 Options Blank Threaded Hole TH Through Hole Maximum Output Power Page ...