ES195 Chemtronics, ES195 Datasheet - Page 5

• Manufacturer Part Number: ES195
• Description: Flux Remover, Flux-Off No Clean, 1 gal
• Manufacturer: Chemtronics
• Type: Flux Removerr

Specifications of ES195

• Chemical Component: 1, 2-Dichloroethylene/Methanol/Tetrahydrofuran
• Dispensing Method: Aerosol
• Primary Type: Cleaner
• Special Features: No-Clean
• Weight: 1 gal.

ITW CHEMTRONICS
NFPA and HMIS Codes:
Health
Flammability
Reactivity
Personal Protection
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Clear colorless liquid
Odor: Ethereal
pH: NA
Vapor Pressure: 205 mm Hg @68 F
Vapor Density: >1
(Air = 1)
Boiling Point: 99 F (37C)
SECTION 10: STABILITY AND REACTIVITY
Stability: - This product is stable. Conditions to Avoid: Do not spray near open flames, red hot surfaces or other sources of ignition.
Incompatibility: Do not mix with powdered alkali and alkaline earth metals or strong oxidizing agents.
Products of Decomposition: Thermal decomposition may release carbon monoxide, carbon dioxide and incompletely burned hydrocarbons as well as hydrochloric and
hydrofluoric acid vapor.
Hazardous Polymerization: Will not occur
SECTION 11: TOXICOLOGICAL INFORMATION:
Inhalation:
Methanol
HCFC-225ca
HCFC-225cb
trans-1,2-dichloroethylene
Tetrahydrofuran
Eye:
trans-1,2-dichloroethylene
HCFC-225ca/HCFC-225cb
Tetrahydrofuran
Cancer Information: No ingredients listed as human carcinogens by NTP or IARC
Reproductive effects: none
SECTION 12: ECOLOGICAL INFORMATION
Environmental Impact Information
Avoid runoff into storm sewers and ditches which lead to waterways. Water runoff can cause environmental damage.
REPORTING
US regulations require reporting spills of this material that could reach any surface waters. The toll free number for
the US Coast Guard National Response Center is: 1-800-424-8802
SECTION 13: DISPOSAL CONSIDERATIONS
Dispose of in accordance with all federal, state and local regulations. Water runoff can cause environmental damage.
SECTION 14: TRANSPORTATION INFORMATION
Air & Ground: Cleaning Compound, Not Regulated
SECTION 15: REGULATORY INFORMATION
SECTION 313 SUPPLIER NOTIFICATION This product contains the following toxic chemicals subject to the reporting requirements of Section 313 of the
Emergency Planning and Community Right-To-Know Act of 1986 (40 CFR 372).
Chemical Name
HCFC-225ca
HCFC-225cb
Methanol
This information should be included on all MSDSs copied and distributed for this material.
TOXIC SUBSTANCES CONTROL ACT (TSCA).
WHMIS: Class D2B
This product has been classified according to the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR.
SECTION 16: OTHER INFORMATION:
Normal ventilation for standard manufacturing practices is usually adequate. Local exhaust should be used when large amounts are released.
To the best of our knowledge, the information contained herein is accurate. However, all materials may present unknown hazards and should be used with caution. In
particular, improper use of our products and their inappropriate combination with other products and substances may produce harmful results which cannot be
anticipated. Final determination of the suitability of any material is the sole responsibility of the user. Although certain hazards are described herein, we cannot
guarantee that these are the only hazards that may exist.
Shipping Name
Proper
LC50 rat
LC50 rat
LC50 rat
LC50 rat
LC50 Rat
rabbit
Conditions to Avoid: NA
All ingredients of this product are listed on the TSCA Inventory.
Moderate irritant
18,000ppm/4hrs
64,000 ppm/4 hrs
37,300 ppm/4 hrs
36,800 ppm/4 hrs
24,100 ppm/4 hrs
Not an irritant
Teratogenic effects: none
MOD – SEV
NFPA
Page 2 of 2
1
-
422-56-0
507-55-1
0
1
CAS#
67-56-1
Solubility in Water: Negligible
Specific Gravity: (Water =1) 1.34
Evaporation Rate: >1
(Butyl acetate=1):
Viscosity: 1 (Approx.)
(Water = 1)
Percent Volatile: 100%
Ingestion:
trans-1,2-dichloroethylene LD50 rat
HCFC-225ca
HCFC-225cb
Skin
Tetrahydrofuran
Tetrahydrofuran
trans-1,2-dichloroethylene LD50 rabbit
Methanol
HCFC-225ca/HCFC-225cb LD50 rabbit
Mutagenic effects: none
HMIS
LD50
LD50
LD50 rat
LD50 rabbit
1
0
1
B
Wt. % Range
MSDS #0309L
10.0-20.0
10.0-20.0
1.0-3.0
Severe irritant
15,800 mg/kg
>2,000 mg/kg
>5,000 mg/kg
>5,000 mg/kg
>5,000 mg/kg
>5,000 mg/kg
3240 mg/kg