JW175H1 Lineage Power, JW175H1 Datasheet
JW175H1
Available stocks
Related parts for JW175H1
JW175H1 Summary of contents
Page 1
Data Sheet April 2008 JW050H, JW075H, JW100H, JW150H, JW175H Power Modules: dc-dc Converters Vdc Input, 24 Vdc Output 175 The JW-Series Power Modules use advanced, surface-mount technology and deliver high-quality, efficient, and compact dc-dc ...
Page 2
... I, max I — — I, max I — — I, max I — — I, max — — I — — — 60 April 2008 Max Unit 75 Vdc 80 Vdc 100 V 1500 Vdc 100 °C 125 °C Max Unit 75 Vdc 1.7 A 2.55 A 3.4 A 5 — mAp-p — dB Lineage Power ...
Page 3
... Load Change from I = 50 Peak Deviation Settling Time (V < 10% of peak deviation Please consult your sales representative or the factory. † These are manufacturing test limits. In some situations, results may differ. Lineage Power (continued) Device Symbol All V O, set All V All — ...
Page 4
... I — — 1.0 on/off V — — 15 on/off I — — 50 on/off — — — — — 0.5 — 60 — 110 V 26.5* — 33.0* O, clamp T — 105 — C Lineage Power Unit pF M¾ Unit hours g (oz.) Unit µ nom V °C ...
Page 5
... INPUT VOLTAGE, V Figure 1. Typical JW050H Input Characteristics at Room Temperature 3.0 2.5 2.0 1.5 1.0 0.5 0 INPUT VOLTAGE, V Figure 2. Typical JW075H Input Characteristics at Room Temperature Lineage Power 4.0 3.5 3.0 2.5 2.0 1.5 1.0 0.5 0 (V) I 8-1159 (C) Figure 3. Typical JW100H Input Characteristics ...
Page 6
... O 8-1286 (C) Figure 8. Typical JW100H Output Characteristics April 2008 OUTPUT CURRENT Room Temperature 1.5 2.0 2.5 3.0 3.5 4.0 4.5 5.0 5.5 6.0 OUTPUT CURRENT Room Temperature Lineage Power 5 6 8-1287 (C) 6.5 8-1288 (C) ...
Page 7
... Converters Vdc Input, 24 Vdc Output 175 W April 2008 Characteristic Curves (continued OUTPUT CURRENT, I Figure 9. Typical JW150H Output Characteristics at Room Temperature OUTPUT CURRENT, I Figure 10. Typical JW175H Output Characteristics at Room Temperature Lineage Power 0 (A) O 8-1289 (C) Figure 11. Typical JW050H Converter Efficiency vs 0.8 (A) O 8-2529 (C) Figure 12 ...
Page 8
... O 8-1292 (C) Figure 15. Typical JW175H Converter Efficiency vs (A) O 8-1293 (C) Figure 16. Typical JW150H Output Ripple Voltage at April 2008 OUTPUT CURRENT, I (A) O Output Current at Room Temperature TIME µs/div) Room Temperature Input, I Load Lineage Power 7 8 8-2528 (C) 8-2017 (C) = Full O ...
Page 9
... Figure 18. Typical JW150H Transient Response to Step Increase in Load from 50% to 75% of Full Load at Room Temperature and 48 V Input (Waveform Averaged to Eliminate Ripple Component.) Lineage Power 8-2019 (C) Note: Tested with a 10 µF aluminum and a 1.0 µF ceramic capacitor across the load. ...
Page 10
... For other highly inductive source impedances, consult the factory for further application guidelines. April 2008 SENSE(+) CONTACT AND DISTRIBUTION LOSSES V (+) V (+) SUPPLY V (–) V (– CONTACT RESISTANCE SENSE(– (+) – V (–) ⎛ ⎞ x 100 ----------------------------------------------- - ⎝ ⎠ (+) – V (– Measurement Test Setup Lineage Power LOAD 8-749 (C) % ...
Page 11
... The unit operates normally once the output current is brought back into its specified range. Lineage Power Remote On/Off Two remote on/off options are available. Positive logic remote on/off turns the module on during a logic-high voltage on the ON/OFF pin, and off during a logic low ...
Page 12
... Figure 27 Δ% ) 100 + 2Δ% 100 + ⎛ ⎞ kΩ --------------------------------- - = ------------------------------------- - – ⎝ ⎠ Δ% 1.225Δ% (+) and V (–) terminals O O Lineage Power ...
Page 13
... O ON/OFF SENSE(+) CASE TRIM V (–) SENSE (– (–) O Figure 27. Circuit Configuration to Increase Output Voltage Lineage Power 100M 10M 1M R LOAD R adj-down 100k 0 8-748 (C).b Figure 28. Resistor Selection for Increased Output Voltage Output Overvoltage Protection The output overvoltage clamp consists of control cir- cuitry, independent of the primary regulation loop, that monitors the voltage on the output terminals ...
Page 14
... CONV.) (20 ft./min LOCAL AMBIENT TEMPERATURE Heat Sink; Either Orientation Lineage Power April 2008 80 90 100 (°C) A 8-1150 (C).a ...
Page 15
... OUTPUT CURRENT, I Figure 31. JW050H Power Dissipation vs. Output Current 0.0 0.5 1.0 1.5 OUTPUT CURRENT, I Figure 32. JW075H Power Dissipation vs. Output Current Lineage Power (continued) (continued Figure 33. JW100H Power Dissipation vs. 1.5 2.0 (A) O 8-1295 ( 2.0 2.5 3.0 Figure 34. JW150H Power Dissipation vs. ...
Page 16
... IN. HEAT SINK 1/2 IN. HEAT SINK 1/4 IN. HEAT SINK NO HEAT SINK 0 0.5 1.0 1.5 2.0 (100) (200) (300) (400) AIR VELOCITY MEASURED IN m/s (ft./min.) Curves; Either Orientation = 54 V and an output current 4 ° ° using Figure 33 Lineage Power 2.5 3.0 (500) (600) 8-1153 (C) ...
Page 17
... This equation pro- vides a conservative estimate for such instances. Lineage Power Solder, Cleaning, and Drying (continued) Considerations Post solder cleaning is usually the final circuit-board assembly process prior to electrical testing ...
Page 18
... TRIM ON/OFF +SEN V (+) V (+) I O 48.26 (1.900) TERMINALS 4.8 48.3 (1.90) (0.19) April 2008 2.06 (0.081) DIA SOLDER-PLATED BRASS 2 PLACES (–OUTPUT AND +OUTPUT) MOUNTING INSERTS M3 x 0.5 THROUGH 4 PLACES 10.16 (0.400) 17.78 (0.700) 25.40 (1.000) 35.56 (1.400) Lineage Power 8-1945 (C).a ...
Page 19
... W positive 175W positive 35.56 (1.400) 25.40 (1.000) 61.0 17.78 (2.40) (0.700) MAX MOUNTING INSERTS Device Comcode Code JW050H1 107430258 JW075H1 107477283 JW100H1 107430282 JW150H1 107253197 JW175H1 108180720 JW050H 107477358 JW075H 107430266 JW100H 107477572 JW150H 107477432 JW175H TBD 8-1945 (C).a 19 ...
Page 20
... Li neage Power reserves the right to m ake changes to the produc t( nform ation contai ned herei n wi thout noti ce iabil ity i s ass res their use or appl ic ation ghts under any patent acc om pany the sale of any oduct informati on. © 2008 Lineage Power Corpor ati on, (M esquite, Texas ) Al l Internati onal Rights Res er ved. June 1999 DS99-117EPS (Replaces DS98-093EPS) 1/4 IN ...