LTM4606IV#PBF Linear Technology, LTM4606IV#PBF Datasheet

Page 1

... Industrial Equipment n RF Equipment n L, LT, LTC, LTM, Linear Technology, the Linear logo, µModule and PolyPhase are registered trademarks of Linear Technology Corporation. All other trademarks are the property of their respective owners. Typical applicaTion Ultralow Noise 2.5V/6A Power Supply with 4.5V to 28V Input 4 ...

Page 2

... LEAD FREE FINISH TRAY LTM4606EV#PBF LTM4606EV#PBF LTM4606IV#PBF LTM4606IV#PBF LTM4606MPV#PBF LTM4606MPV#PBF Consult LTC Marketing for parts specified with wider operating temperature ranges. *The temperature grade is identified by a label on the shipping container. For more information on lead free part marking, go to: This product is only offered in trays. For more information go to: ...

Page 3

T application (front page) configuration, R SYMBOL PARAMETER I Input Supply Bias Current Q(VIN) I Input Supply Current S(VIN) INTV V = 12V, RUN > Output Specifications I ...

Page 4

LTM4606 elecTrical characTerisTics operating temperature range, otherwise specifications are at T application (front page) configuration, R SYMBOL PARAMETER I Current into DRV Pin DRVCC CC R Resistor Between V and V FBHI OUT RUN Volts From RUN to GND Maximum ...

Page 5

Typical perForMance characTerisTics Efficiency vs Load Current with 5V (FCB = 0) IN 100 0.6V OUT 1.2V OUT 60 1.8V OUT 2.5V OUT 3.3V OUT LOAD CURRENT (A) 4606 G01 ...

Page 6

LTM4606 Typical perForMance characTerisTics –55°C, Start-Up OUT V OUT 0.5V/DIV I IN 0.5A/DIV 4606 G10 1ms/DIV V = 12V 1.5V OUT C = 2× 22µF , 10V CERAMIC OUT 1× 100µF , 6.3V CERAMIC ...

Page 7

FuncTions V (Bank 1): Power Input Pins. Apply input voltage be- IN tween these pins and PGND pins. Recommend placing input decoupling capacitance directly between V and PGND pins. V (Bank 3): Power Output Pins. Apply output load OUT ...

Page 8

LTM4606 pin FuncTions RUN (Pins A10, B9): Run Control Pins. A voltage above 1.9V will turn on the module, and below 1V will turn off the module. A programmable UVLO function can be ac- complished with a resistor from V ...

Page 9

DiagraM >1. <1V = OFF MAX = 5V RUN PGOOD COMP INTERNAL COMP SGND MARG1 MARG0 SET FB 19.1k 41.2k FCB 10k MPGM TRACK/SS PLLIN C SS 4.7µF INTV CC DRV CC Decoupling ...

Page 10

LTM4606 operaTion Power Module Description The LTM4606 is a standalone non-isolated switching mode DC/DC power supply. It can deliver output current with some external input and output capacitors. This module provides precisely regulated output voltage ...

Page 11

The typical LTM4606 application circuit is shown in Fig- ure 20. External component selection is primarily deter- mined by the maximum load current and output voltage. Refer to Table 2 for specific external capacitor requirements for a particular ...

Page 12

LTM4606 applicaTions inForMaTion Without considering the inductor ripple current, the RMS current of the input capacitor can be estimated as: I OUT(MAX) I • D • 1– CIN(RMS) η In the above equation, η is the estimated ...

Page 13

Figure 3. Normalized Output Ripple Current vs Duty Cycle, Dlr = V Fault ...

Page 14

LTM4606 applicaTions inForMaTion Output Voltage Tracking Output voltage tracking can be programmed externally using the TRACK/SS pin. The output can be tracked up and down with another regulator. Figure 4 shows an example of coincident tracking where the master regulator’s ...

Page 15

PLLIN The power module has a phase-locked loop comprised of an internal voltage controlled oscillator and a phase detector. This allows the internal top MOSFET turn- locked to the rising edge of the external clock. The ...

Page 16

LTM4606 applicaTions inForMaTion 2.5 2.0 12V LOSS 1.5 1.0 0 OUTPUT CURRENT (A) Figure 6. 1.5V Power Loss 1.5V , 0LFM 1 IN OUT 5V , 1.5V ...

Page 17

IN OUT 12V , 3.3V , 200LFM IN OUT 12V , 3.3V , 400LFM IN OUT AMBIENT TEMPERATURE (°C) Figure 12. No Heat ...

Page 18

LTM4606 applicaTions inForMaTion Table 2. Output Voltage Response vs Component Matrix (Refer to Figure 20) TYPICAL MEASURED VALUES C VENDORS PART NUMBER OUT1 TAIYO YUDEN JMK316BJ226ML-T501 (22µF , 6.3V) TAIYO YUDEN JMK325BJ476MM-T (47µF , 6.3V) TDK C3225X5R0J476M (47µF , 6.3V) ...

Page 19

Table 3. 1.5V Output DERATING CURVE V (V) IN Figures Figures Figures Figures Figures Figures ...

Page 20

LTM4606 applicaTions inForMaTion Frequency Adjustment The LTM4606 is designed to typically operate at 800kHz across most input conditions. The f open or decoupled with an optional 1000pF capacitor. The switching frequency has been optimized for maintaining constant output ripple noise ...

Page 21

Typical applicaTions 10V TO 28V C IN 10µF 35V CERAMIC x2 TRACK/SS CONTROL 4.5V TO 28V C IN 10µF 35V CERAMIC OUT C1 10µ PLLIN 100k 100k PGOOD OUT RUN ...

Page 22

LTM4606 Typical applicaTions 4.5V TO 28V C IN 10µF 35V CERAMIC 4.5V TO 28V + 2-PHASE OSCILLATOR + V OUT1 GND OUT2 C7 R5 0.1µF 118k SET MOD LTC6908 OUT CLOCK SYNC C1 10µF R4 ...

Page 23

Typical applicaTions 28V + 2-PHASE OSCILLATOR + V OUT1 GND OUT2 C9 R5 0.1µF 118k SET MOD LTC6908-1 Figure 22. 2-Phase, 3.3V and 2.5V Outputs at 6A with Tracking and Margining 3.3V C3 10µF CLOCK SYNC ...

Page 24

LTM4606 Typical applicaTions 4.5V TO 28V + 2-PHASE OSCILLATOR + V OUT1 C9 GND OUT2 R5 0.1µF 182k SET MOD LTC6908-1 Figure 23. 2-Phase, 1.8V and 1.5V Outputs at 6A with Tracking and Margining 24 1.8V C3 10µ ...

Page 25

DescripTion PIN NAME ...

Page 26

LTM4606 package DescripTion bbb 6.9850 5.7150 4.4450 3.1750 1.9050 0.6350 0.0000 0.6350 1.9050 3.1750 4.4450 5.7150 6.9850 4606fb ...

Page 27

... Added value of 1µH to inductor on Figure 1. Updated Related Parts. Information furnished by Linear Technology Corporation is believed to be accurate and reliable. However, no responsibility is assumed for its use. Linear Technology Corporation makes no representa- tion that the interconnection of its circuits as described herein will not infringe on existing patent rights. LTM4606 ...

Page 28

... LGA Package OUT ≤ 36V, 9mm × 11.25mm × 2.8mm LGA Package IN ≤ 36V, 0.8V ≤ V ≤ 10V, IN OUT ≤ 24V, 11.25mm × 15mm × 4.32mm LGA Package OUT LT 0311 REV B • PRINTED IN USA  LINEAR TECHNOLOGY CORPORATION 2008 4606fb ...