mc33899vwr2 Freescale Semiconductor, Inc, mc33899vwr2 Datasheet
mc33899vwr2
Related parts for mc33899vwr2
mc33899vwr2 Summary of contents
Page 1
... Pb-Free Packaging Designated by Suffix Code VW V DDL MCU Figure 1. 33899 Simplified Application Diagram * This document contains certain information on a new product. Specifications and information herein are subject to change without notice. © Freescale Semiconductor, Inc., 2007. All rights reserved. PROGRAMMABLE H-BRIDGE POWER IC Device MC33899VW/R2 33899 V +5.0 V ...
Page 2
INTERNAL BLOCK DIAGRAM Charge CRES Pump VCC +3.3 V Internal VCCL Regulator CSNS LSCMP FWD REV PWM EN1 EN2 VDDQ SCLK Figure 2. 33899 Simplified Internal Block Diagram 33899 2 INTERNAL BLOCK DIAGRAM VIGNP To Gate Drives ...
Page 3
VDDQ SCLK CRES REDIS VIGNP VIGNP GND LSCMP EN2 Table 1. 33899 Pin Definitions A functional description of each pin can be found in the Functional Pin Description section beginning on Pin Number Pin Name Formal Name 1 VDDQ Logic ...
Page 4
PIN CONNECTIONS Table 1. 33899 Pin Definitions (continued) A functional description of each pin can be found in the Functional Pin Description section beginning on Pin Number Pin Name Formal Name 24 RS Slew Rate Control 25 PWM PWM Input ...
Page 5
Table 2. Maximum Ratings All voltages are with respect to ground unless otherwise noted. Exceeding these ratings may cause a malfunction or permanent damage to the device. Ratings ELECTRICAL RATINGS Protected Power Supply Voltage Logic Supply Voltage Logic Output Bias ...
Page 6
ELECTRICAL CHARACTERISTICS STATIC ELECTRICAL CHARACTERISTICS STATIC ELECTRICAL CHARACTERISTICS Table 3. Static Electrical Characteristics Characteristics at - 40°C ≤ T ≤ +150°C, 4.75 V ≤ ≤ 26.5 V unless otherwise noted. Typical values reflect the approximate parameter means at ...
Page 7
Table 3. Static Electrical Characteristics (continued) Characteristics at - 40°C ≤ T ≤ +150°C, 4.75 V ≤ ≤ 26.5 V unless otherwise noted. Typical values reflect the approximate parameter means at T unless otherwise noted. Characteristic CONTROL INPUTS ...
Page 8
ELECTRICAL CHARACTERISTICS STATIC ELECTRICAL CHARACTERISTICS Table 3. Static Electrical Characteristics (continued) Characteristics at - 40°C ≤ T ≤ +150°C, 4.75 V ≤ ≤ 26.5 V unless otherwise noted. Typical values reflect the approximate parameter means at T unless ...
Page 9
DYNAMIC ELECTRICAL CHARACTERISTICS Table 4. Dynamic Electrical Characteristics Characteristics at - 40°C ≤ T ≤ 125°C, 4.75 V ≤ reflect the approximate parameter means at T Characteristic (8) PWM Frequency PWM / Output Duty Cycle Accuracy Frequency = ...
Page 10
ELECTRICAL CHARACTERISTICS DYNAMIC ELECTRICAL CHARACTERISTICS Table 4. Dynamic Electrical Characteristics Characteristics at - 40°C ≤ T ≤ 125°C, 4.75 V ≤ reflect the approximate parameter means at T Characteristic (12) SPI CHARACTERISTICS (13) Transfer Frequency (13) SCLK Period ...
Page 11
LEAD SCLK_HS SCLK t DO(ACC) DO MSB OUT t DI(SU) DI MSB IN 5.0V V ENx V S0-S1 @100mA V S0-S1 Analog Integrated Circuit Device Data Freescale Semiconductor TIMING DIAGRAMS t SCLK_LS t DO(VALID) DATA LSB OUT ...
Page 12
FUNCTIONAL DESCRIPTION INTRODUCTION The 33899 is a programmable H-Bridge, power integrated circuit (IC) designed to drive DC motors or bi-directional solenoid controlled actuators, such as throttle control or exhaust gas recirculation actuators particularly well suited for the harsh ...
Page 13
EN1 EN2 0 1 Disabled (Standby Mode Disabled (Standby Mode Enabled (Run Mode) INPUT CONTROL OF H-BRIDGE (PWM) The PWM input pin controls the sequencing of the PWM’ing high-side and low-side MOSFETs. A logic [1] commands ...
Page 14
FUNCTIONAL DESCRIPTION FUNCTIONAL PIN DESCRIPTION LOAD CURRENT FEEDBACK (CSNS) The load current sense circuit mirrors a sample of the load current back to the microcontroller via the CSNS pin supplies a current that is 1/400 of the load ...
Page 15
PWM REDIS (nF) µ µs t min Figure 9. Re-enable after a Low Side Current Comparator Trip LOW-SIDE CURRENT COMPARATOR VS. CURRENT LIMIT LEVELS There are two different current limit thresholds for the ...
Page 16
FUNCTIONAL DESCRIPTION FUNCTIONAL PIN DESCRIPTION the input data from the DI input until eventually transitions CS from a logic [ logic [1]. The DO output pin high impedance condition unless is low, at least one ...
Page 17
FUNCTIONAL INTERNAL BLOCK DESCRIPTION Current Sense Temperature Sense Analog Control and Protection SPI Interface Command and Fault Registers MCU Interface and Output Control H-BRIDGE OUTPUT DRIVERS (S0 AND S1) The 33899 Power IC provides the means to efficiently drive a ...
Page 18
FUNCTIONAL INTERNAL BLOCK DESCRIPTION INTRODUCTION The PWM input is connected to the system microprocessor and provides for control of the four MOSFET outputs. The PWM duty cycle range 100%; however, open load detection circuits require a minimum ...
Page 19
FUNCTIONAL DEVICE OPERATION Short-to-GND or Short-to-VIGNP Fault Filtering The 33899 has a short-to-GND and short-to-VIGNP digital fault filter. After a single fault occurrence, another 7 shorts consecutive with PWM must be detected before the bit is latched into the fault ...
Page 20
FUNCTIONAL DEVICE OPERATION OPERATIONAL MODES EN1 EN2 kΩ 0. SGFON 0. SBFON 12 kΩ Note SGFON and SBFON are ON-State Fault. Figure 13. OFF-State Fault Detection Diagram In the full ...
Page 21
Fault Detection During ON State While the H-Bridge circuit is in operation (i.e., when a high- side MOSFET is ON), the 33899 is capable of detecting both shorts to VIGNP and shorts to ground. A short will cause the appropriate ...
Page 22
FUNCTIONAL DEVICE OPERATION LOGIC COMMANDS AND REGISTERS SPI INTERFACE AND REGISTER DESCRIPTION SPI Control Register Definition An 8-bit SPI allows the system microprocessor to clear the Fault register, select a programmable current limit, and select Table 8. SPI Control Register ...
Page 23
For the most current package revision, visit www.freescale.com and perform a keyword search using the “98A” listed below. Analog Integrated Circuit Device Data Freescale Semiconductor PACKAGING PACKAGE DIMENSIONS VW SUFFIX 30-PIN HSOP 98ASH70693A ISSUE A PACKAGING PACKAGE DIMENSIONS 33899 23 ...
Page 24
PACKAGING PACKAGE DIMENSIONS (CONTINUED) For the most current package revision, visit www.freescale.com and perform a keyword search using the “98A” listed below. 33899 24 PACKAGE DIMENSIONS (CONTINUED) VW SUFFIX 30-PIN HSOP 98ASH70693A ISSUE A Analog Integrated Circuit Device Data Freescale ...
Page 25
REVISION DATE DESCRIPTION OF CHANGES 6/2006 • Initial Release 2.0 Analog Integrated Circuit Device Data Freescale Semiconductor REVISION HISTORY REVISION HISTORY 33899 25 ...
Page 26
... Freescale Semiconductor was negligent regarding the design or manufacture of the part. Freescale™ and the Freescale logo are trademarks of Freescale Semiconductor, Inc. All other product or service names are the property of their respective owners. © Freescale Semiconductor, Inc., 2007. All rights reserved. ...