tea1553t NXP Semiconductors, tea1553t Datasheet
tea1553t
Available stocks
Related parts for tea1553t
tea1553t Summary of contents
Page 1
... TEA1553T GreenChip II SMPS control IC Rev. 01 — 3 July 2007 1. General description The GreenChip II is the second generation of green Switched Mode Power Supply (SMPS) controller ICs operating directly from the rectified universal mains. A high level of integration leads to a cost effective power supply with a very low number of external components. The special built-in green functions allow optimum effi ...
Page 2
... W. 4. Ordering information Table 1. Ordering information Type number Package Name TEA1553T SO16 TEA1553T_1 Product data sheet Description plastic small outline package; 16 leads; body width 3.9 mm Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC Version SOT109-1 © NXP B.V. 2007. All rights reserved ...
Page 3
... VCOADJ 1 I prot(CTRL) POWER-ON CTRL 14 1 MINIMUM FREQ. 300 ENABLING AND CSTART 15 TIMING 5.6 V 300 LOCK 13 5.6 V 2.5 V OVERTEMPERATURE Fig 1. Block diagram of TEA1553T TEA1553T_1 Product data sheet SUPPLY MANAGEMENT CURRENT SOURCE START INTERNAL UVLO SUPPLY LOGIC 80 mV LOGIC RESET UVLO MAXIMUM ...
Page 4
... NXP Semiconductors 6. Pinning information 6.1 Pinning Fig 2. Pin configuration for TEA1553T 6.2 Pin description Table 2. Symbol VCOADJ OVPFCAP ISENSE STDBY DRIVER HVS HVS DRAIN V CC n.c. GND VCC5V LOCK CTRL CSTART DEM TEA1553T_1 Product data sheet VCO ADJ 1 OVPFCAP 2 ISENSE 3 STDBY 4 5 DRIVER ...
Page 5
... NXP Semiconductors 7. Functional description The TEA1553T is a controller for a compact flyback converter, with the IC situated on the primary side. An auxiliary winding of the transformer provides demagnetization detection and powers the IC after start-up. V MAINS ( 600 V MOSFET is used, the DRAIN connection can be made directly to the Vin; a Fig 3 ...
Page 6
... V or VCC (switch S1 will be opened); see VCC drops below the V CC Figure 14 Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC quasi-resonant POWER 014aaa002 mains(oper)(en) Figure 1. The IC will activate the passes the V level ...
Page 7
... Product data sheet Figure 5 and Figure V sense(max) 0. (TYP) voltage as a function of V sense(max kHz VCO 2 LEVEL Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC 6). 1 CTRL (TYP) 014aaa003 CTRL 125 kHz VCO V 1 sense(max) LEVEL 014aaa005 sense (max) © ...
Page 8
... TEA1553T_1 Product data sheet level), when the minimum frequency is reached. 2 CURRENT COMPARATOR 1 CTRL CTRL VCC5V VCOADJ Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC Figure 8.) The frequency reduction will stop DRIVER DRIVER ISENSE V OSCILLATOR I will be sense Figure 7). ...
Page 9
... The level at which the VCO mode of operation starts/ends can be externally controlled with the VCOADJ pin. Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control (V) VCOADJ Vx (V) ...
Page 10
... Overvoltage protection An OVP mode is implemented in the GreenChip series. For the TEA1553T, this works by sensing the auxiliary voltage via the current flowing into pin DEM during the secondary stroke. The auxiliary winding voltage is a well-defined replica of the output voltage. Any voltage spikes are averaged by an internal fi ...
Page 11
... Rev. 01 — 3 July 2007 GreenChip II SMPS control pos is the number of auxiliary turns of aux , can be adjusted to the turns ratio of the DEM ---------------------------------------------------- - 2 is the capacitance on d TEA1553T © NXP B.V. 2007. All rights reserved ...
Page 12
... TEA1553T_1 Product data sheet primary secondary stroke stroke drain valley secondary stroke oscillator aux mains -------------------------- - R DEM DEM N aux N = ----------- N p Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC secondary ringing (2) (1) 014aaa027 © NXP B.V. 2007. All rights reserved leb ...
Page 13
... A is injected into the external soft-start resistor and AOP Figure 11 and Figure I AOP ( function of V AOP SENSE SENSE Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC V sense(max) 0.52 V (TYP) 0.30 V (TYP) 120 A (TYP) 014aaa009 voltage and the SENSE 12 ...
Page 14
... V CC pin will cycle between V CC Figure 3 internal Zener clamp of 5.6 V will protect this pin from excessive Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC DRIVER R SS ISENSE sense 014aaa011 has been removed), the IC will stop ...
Page 15
... V CC voltage drops below a level of about 4 startup(soft) and the V level, the I startup Figure 13). is subtracted from pin V charging current, the R CC TEA1553T level, however the level, th(UVLO with a ss current startup(soft) SS © NXP B.V. 2007. All rights reserved ...
Page 16
... Electromagnetic Interference (EMI) and also limits the current spikes across R TEA1553T_1 Product data sheet I startup(soft) startup 0.5 V DRIVER ISENSE overcurrent protection voltage Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control sense C SS 014aaa012 . sense © NXP B.V. 2007. All rights reserved ...
Page 17
... DRIVER current on pin DRAIN output current on pin VCC5V current on pin CTRL current on pin DEM total power T < amb dissipation storage temperature Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC may not be current CC Min Max Unit 0.4 +650 V ...
Page 18
... Conditions pin CC I DRAIN > 100 V with auxiliary supply pin DRAIN > 100 startup th(UVLO) Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC may not be current CC Min Max 20 +145 [1] - 2000 [1] - 1500 [2] - 200 resistor. ...
Page 19
... ISENSE, where frequency reduction starts. See Figure 6 and Figure 8 peak voltage at pin ISENSE, where the frequency is equal to f osc(low) input current pin I CTRL = 1.5 V current on pin VCC5V = 1 mA Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC Min Typ Max 1.2 1 0.8 1.2 0.75 0.45 650 550 450 1.1 1.3 1.5 ...
Page 20
... SENSE < 0 pin CTRL < 0 and V on pin CSTART > pin SENSE < 0 [2] [ pin OVPFCAP = [ pin OVPFCAP = Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC Min Typ Max 2.37 2.5 2. 11.5 10 8.5 2.37 2.5 2.63 11.5 10 8.5 20 ...
Page 21
... pin DRIVER = 9 see Section 7.9 “Overvoltage protection”. DEM Section 7.9 “Overvoltage protection”. ; see Section 7.12 “Overpower protection”. DEM Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC Min Typ Max [4] 103 90 77 [5] 145 170 195 [6] - 120 - [7] - 500 - 4 ...
Page 22
... NXP Semiconductors 11. Application information A converter using the TEA1553T consists of an input filter, a transformer with a third winding (auxiliary), and an output stage with a feedback circuit. Capacitor C high voltage rectified mains during start-up and via the auxiliary winding during operation. A sense resistor converts the primary current into a voltage at pin ISENSE (pin 3). The value of this sense resistor defi ...
Page 23
... NXP Semiconductors DRAIN DRIVER V mains(oper(en) V CC5V start-up normal sequence operation Fig 15. Typical waveforms TEA1553T_1 Product data sheet ovp Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC normal output operation short-circuit 014aaa014 © NXP B.V. 2007. All rights reserved ...
Page 24
... 0.49 0.25 10.0 4.0 1.27 0.36 0.19 9.8 3.8 0.019 0.0100 0.39 0.16 0.244 0.05 0.014 0.0075 0.38 0.15 0.228 REFERENCES JEDEC JEITA MS-012 Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control detail 6.2 1.0 0.7 1.05 0.25 0.25 5.8 0.4 0.6 0.039 0.028 ...
Page 25
... NXP Semiconductors 13. Revision history Table 6. Revision history Document ID Release date TEA1553T_1 20070703 TEA1553T_1 Product data sheet Data sheet status Change notice Product data sheet - Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC Supersedes - © NXP B.V. 2007. All rights reserved ...
Page 26
... Trademarks Notice: All referenced brands, product names, service names and trademarks are the property of their respective owners. GreenChip — trademark of NXP B.V. http://www.nxp.com salesaddresses@nxp.com Rev. 01 — 3 July 2007 TEA1553T GreenChip II SMPS control IC © NXP B.V. 2007. All rights reserved ...
Page 27
... Please be aware that important notices concerning this document and the product(s) described herein, have been included in section ‘Legal information’. © NXP B.V. 2007. For more information, please visit: http://www.nxp.com For sales office addresses, please send an email to: salesaddresses@nxp.com TEA1553T All rights reserved. Date of release: 3 July 2007 Document identifier: TEA1553T_1 ...